臺灣博碩士論文加值系統

LLC諧振轉換器之控制電路具有固定責任週期的優點，並利用主變壓器一次側漏電感、激磁電感、MOSFET之寄生元件及諧振電容產生諧振現象，可降低切換損失並且提高效率。本實驗電路為115V ~ 264Vac輸入，19V/4.73A輸出，轉換器在滿載狀況下可達到95.31%的效率。

本篇論文在研究LLC諧振轉換器之設計及製造加以探討並實際量測。LLC諧振轉換器具有架構簡單、體積小，不須附加元件，並利用寄生元件及諧振零電壓切換技術，減少寄生元件引起的不良效應，使開關元件具有零電壓導通切換特性，降低開關元件切換應力，使其在頻率高頻操作時仍可正常操作。

The LLC resonant converter has the merit of fixed duty cycle operation. A combination of parasitic components, which includes the MOSFET output capacitance and the leakage inductance of the isolation transformer, produces a resonant action and reduces drain-source voltage prior to turn-on. Moreover, the switching loss is reduced relatively.Therefore, high efficiency operation of system is achieved.An experimental prototype of 115~264Vac input, 19V/4.73A output, the resonant converter full load efficient reaches 95.31%.

The subject of this thesis is to analyze and design a LLC resonant converter. The LLC resonant converter allows zero voltage turn-on of switches while retaining the merits of simple circuit designed and low stresses accompanied with variable frequency control. The LLC resonant converter uses parasitic components to resonate. Therefore, additional resonant components are not required. Moreover, the switching stresses are reduced by using of the zero voltage switching (ZVS) resonant technique.

第一章 緒論 1
1.1 研究背景與動機 1
1.2 論文架構 2
第二章 柔性切換架構之發展 3
2.1 概述 3
2.2 開關元件 3
2.3 切換損失 4
2.4 零電壓切換 5
2.5 柔性切換架構之演進 7
第三章 LLC諧振式轉換器由來與構造 14
3.1 傳統電源供應器 14
3.2 LLC諧振式轉換器優點 15
3.2.1 整合磁性元件之變壓器 16
3.3 系統架構 17
3.4 LLC電路分析 22
第四章 LLC諧振式轉換器工作原理 30
4.1 概述 30
4.2 階段一電路動作原理說明 30
4.3 階段二電路動作原理說明 40
4.4 階段三電路動作原理說明 49
第五章 LLC諧振式轉換器實體規格與量測波形 61
5.1 設計電路圖 61
5.2 測試環境 62
5.3 LLC 諧振式轉換器參數設計與電器規格表 63
5.4 LLC諧振式轉換器效率改善 66
5.5 LLC諧振式轉換器實測波形 77
5.5.1 輸入交流264Vac實測波形 77
5.5.2 輸入交流230Vac實測波形 81
5.5.3 輸入交流115Vac實測波形 83
5.6 小結 86
第六章 結論 87
6.1 總結 87
6.2 未來研究方向 88
參考文獻 89

[1] 梁適安，”交換式電源供給器之理論與實務設計”，全華科技圖書股份有限公司，中華民國86年8月。
[2] 鄭振東編譯，”新型柔性交換式電源技術入門”，全華科技圖書股份有限公司，中華民國92年8月。
[3] 陳佐民，”不對稱半橋反磁式轉換器之穩態直流與動態小訊號分析”，國 立台灣大學博士論文，中華民國92年6月。
[4] 鄭振東，”交換式電源手冊”，全華科技圖書股份有限公司， 2001。
[5] 黃賢德，”高效率LLC諧振式切換式電源供應器電路之設計與分析”，國立東華大學碩士論文，中華民國95年7月。
[6] R. Oruganti, J. J. Yang, and F. C. Lee, “Implementation of optimal trajectory control of series resonant converter,” IEEE Trans. Power Electronics, vol.3, no.3, pp.318-327, 1988.
[7] F. S. Tsai and F. C. Lee, “A complete DC characterization of a constant -frequency, clamped-mode, series resonant converter,” IEEE Power Electronics Specialists Conference, 1988, vol.2, no.1, pp.87-996.
[8] H. Jiang, G. Maggetto, and P. Lataire, “Steady-state analysis of the series resonant DC-DC converter in conjunction with loosely coupled transformer-above resonance operation,” IEEE Trans. Power Electronics, vol.14, no.3, pp.469-480, 1999.


[9] A. K. S. Bhat, “Analysis and design of a modified series resonant converter,” IEEE Trans. Power Electronics, vol.8, no.4, pp.423-430, 1993.
[10] R. Farrington, M. M. Jovanovic, and F. C. Lee, “Analysis of reactive power in resonant converters,” IEEE Power Electronics Specialists Conference, 1992, vol.1, pp.197-205.
[11] R. P. Severns, “Topologies for three element resonant converters,” IEEE Trans. Power Electronics, vol.7, no.1, pp.89-98, 1992.
[12] B. Yang, F. C. Lee, A. J. Zhang, and G. Huang, “LLC resonant converter for front end DC/DC conversion,” IEEE Applied Power Electronics Conference, 2002, vol.2, pp.1108-1112.
[13] Y. Gu, L. Hang, H. Chen, Z. Lu, H. Qian, and J. Li, “A simple structure of LLC resonant DC-DC converter for multi-output applications,” IEEE Applied Power Electronics Conference, 2005, vol.3, pp.1485-1490.
[14] Y. Liang, W. Liu, B. Lu, and J. D. V. Wyk, “Design of integrated passive component for a 1 MHz 1 kW half-bridge LLC resonant converter,” Industry Applications Conference, vol.3, pp.2223-2228, 2005.
[15] A. K. S. Bhat, “Analysis, optimization and design of a series-parallel resonant converter,” IEEE Applied Power Electronics Conference,1990, pp.155-164.